P0635
Power Steering Control Circuit
- Severity
- Critical
- Driving
- Drive only to a garage
A fault in the power steering control circuit - a general fault, usually a wiring, connector or actuator problem. On a vehicle with electric or electrically assisted steering, this is the circuit that controls the assistance. If it fails, the steering becomes very heavy - the car remains steerable, but it takes far more effort than the driver expects, and that is most noticeable at parking speeds.
Possible causes
- CommonWiring or connector fault on the control circuit
- CommonCorroded connector at the power steering unit
- CommonFailed power steering control module or motor
- CommonLow battery voltage - electric steering draws heavily and drops out on a weak supply
- PossibleBlown fuse or fusible link on the steering supply
- RareFailed control module driver
What you might notice
- Steering much heavier than normal
- Power steering warning light
- Assistance coming and going
- Heavy steering worst when parking
- Check engine light on
What to check, in order
- If the steering has already gone heavy, stop somewhere safe rather than continuing. Assistance that has dropped out once can drop out again.
- Check battery voltage and the terminals. Electric power steering draws a large current and is one of the first things to drop out on a weak supply.
- Check the fuse or fusible link for the steering circuit.
- Inspect the connector at the steering unit for corrosion and water.
- Read all codes - a steering module code alongside this one points at the unit rather than the circuit.
Read this code from your own car
Plug an ELM327 adapter into the OBD-II port under the dashboard. Pin16 reads every stored, pending and permanent code, explains each one like this page does — offline, with no account — and shows what the car recorded when the fault was set.
Where this code sits
P00xxP01xxP02xxP03xxP04xxP05xxP06xxP07xxP08xxP09xxP0AxxP0BxxP0CxxP0DxxP0ExxP0FxxP10xxP11xxP12xxP13xxP14xxP15xxP16xxP17xxP18xxP19xxP1AxxP1BxxP1CxxP1DxxP1ExxP1FxxP20xxP21xxP22xxP23xxP24xxP25xxP26xxP27xxP28xxP29xxP2AxxP2BxxP2CxxP2DxxP2ExxP2FxxP30xxP31xxP32xxP33xxP34xxP35xxP36xxP37xxP38xxP39xxP3AxxP3BxxP3CxxP3DxxP3ExxP3Fxx
Computer output circuits and control module
P0600P0601P0602P0603P0604P0605P0606P0607P0608P0609P0610P0611P0612P0613P0614P0615P0616P0617P0618P0619P0620P0621P0622P0623P0624P0625P0626P0627P0628P0629P0630P0631P0632P0633P0634P0635P0636P0637P0638P0639P0640P0641P0642P0643P0644P0645P0646P0647P0648P0649P0650P0651P0652P0653P0654P0655P0656P0657P0658P0659P0660P0661P0662P0663P0664P0665P0666P0667P0668P0669P0670P0671P0672P0673P0674P0675P0676P0677P0678P0679P0680P0681P0682P0683P0684P0685P0686P0687P0688P0689P0690P0691P0692P0693P0694P0695P0696P0697P0698P0699